1. (Components must be installed by a licensed Mobility Van Convertor):
Door Opening and Closing Systems: Motor/Clutch Assembly; Side Door Lower Track Liner; Door Cables; Rear
Hinge; Door Latch; Solenoid; Door Lock Contacts; Electric Clutch Assembly; Optic Sensor; Pulleys; Seat Base Pretensioner Switch;
Door Operator Control Arm.
Electrical System: Power Wheelchair Tiedown; Power Seat Base; Limit Switches; Control Module;
Delay Switch; Relays; Circuit Breakers; Wiring Harness; Remote Transmitter/Receiver (excluding Batteries).
Fuel System: Filler Neck Hose; Fuel Filler Neck.
Kneel System: Dust Boot for Chain; Actuator; Torsion Spring; Actuator Chain; Limit Switches.
Ramp Systems: Optic Sensor; Ramp Motor; Timing Belt; Mag Switch; Drive Screws; Ramp Release Cable
Assembly; Limit Switch; Releasing 1/2 Nut Assembly, Gate Latch Release Assembly; Large 1/2 Gear; Motor/Clutch Assembly; Ramp
Bearing; Ramp Cable Assembly; Lift Arm; Ramp Hinge.
Lift System: Limit Switches; Hydraulic Pump; Hydraulic Pressure Hoses and Seals; Motor and Clutch
Assembly; Solenoid.
Additional Suspension Coverage: Pannard Bar; Track Bar; Suspension Bumpers; Leaf Springs; Leaf Spring
Shackles & Hardware; Load Assist Shocks; Load Assist Springs; Coil Springs.
Component Group Package (Plan Code MDD – 1–14)
Includes
all parts covered under the Mobility Van Package, plus:
2.
Engine: Cylinder Block, Cylinder Head(s), Rotary Housing
and all internal lubricated parts contained within the engine, including: Pistons;
Piston Rings; Connecting Rod Bearings; Crankshaft; Crankshaft Main Bearings; Camshaft; Camshaft Bearings; Cam Followers; Timing
Chain or Belt; Timing Gears. Guides, Tensioners; Rocker Arms; Rocker Shafts; Rocker Bushings; Cylinder Head Valves; Valve
Guides; Valve Lifters; Valve Springs; Valve Seals; Valve Retainers; Valve Seats; Push Rods; Water Pump; Fuel Pump; Oil Pump
and Oil Pump Housing; Harmonic Balancer; Oil Pan; Timing Chain Cover; Intake and Exhaust Manifolds; Valve Covers; Engine Mounts;
Cam Gear Bolt; Harmonic Balancer Bolt; Head Bolts; Seals and Gaskets.
3.
Turbocharger/Supercharger: (factory installed only) Turbocharger/Supercharger Housing and All Internal
Parts; Seals and Gaskets.
4.
Transmission: (Automatic or Standard) Transmission Case
and all Internal Parts plus: Torque Converter; Flywheel/Flex Plate; Vacuum Modulator;
Electronic Shift Control Unit; Transmission Cooler; Transmission Mounts; Oil Pan; Throw-Out Bearing; Seals and Gaskets.
5.
Transfer Case: Transfer Case and all Internal Parts; Seals
and Gaskets.
6.
Drive Axle: (Front and Rear) Drive Axle Case; All Internal
Parts contained within the Drive Axle; Locking Hubs; Drive Shafts; Center Support Bearings; Universal Joints; Constant Velocity
Joints; Axle Bearings; Four-Wheel Drive Actuator; Differential Cover; Seals and Gaskets.
7.
Steering: All Internal Parts contained within the Steering
Box; Rack and Pinion Gear; Power Steering Pump; Power Steering Hoses; Steering Knuckles; Pitman Arm; Idler Arm; Tie Rod Ends
and Drag Link; Steering Dampener; Upper and Lower Steering Column Shafts and Couplings, including Internal Tilt-Wheel Mechanism;
Steering Box and Rack and Pinion Gear Housings. Rear Wheel Steering: Rear Steering Shaft and Couplings; Power Cylinder and Pump; Electronic Control
Unit/Solenoid; Phase Control Unit; Stepper Motor; Steering Box; Control Valve; Rack; Tie Rod Ends; Seals and Gaskets.
8.
Brakes: Master Cylinder; Power Brake Cylinder; Vacuum/Hydro
Assist Booster; Disc Brake Caliper; Wheel Cylinders; Compensating Valve; Brake Hydraulic Lines and Fittings; Hydraulic Control
Unit; Seals and Gaskets. The following ABS Parts are also covered: Electronic Control Processor; Wheel Speed Sensors; Hydraulic Pump/Motor Assembly; Pressure Modulator Valve/Isolation
Dump Valve; Accumulator; Seals and Gaskets.
9.
Electrical: Alternator; Voltage Regulator; Starter Motor;
Starter Solenoid and Starter Drive; Engine Compartment Wiring Harness; Computerized Timing Control Unit; Electronic Ignition
Module; Crank Angle Sensor; Knock Sensor; Ignition Switch; Ignition Switch Lock Cylinder; Front and Rear Window Wiper Motor,
Washer Pump and Switch; Stop Lamp Switch; Headlamp Switch; Turn Signal Switch; Heater/A.C. Blower Speed Switch; Manual Heater/A.C.
Control Head; Horns; O-2 Sensors.
10.
Air Conditioner: Condenser; Compressor, Compressor Clutch and
Pulley; Air Conditioning Lines and Hoses; Evaporator; Idler Pulley and Idler Pulley Bearing; High/Low Compressor Cut-off Switch;
Expansion Valve; Pressure Cycling Switch. The following parts are also covered
if they are required in connection with the repair of a covered part listed above: Accumulator/Receiver
Driver; Orifice Tube; Oil and Refrigerant.
11.
Front and Rear Suspension: Upper and Lower Control
Arms; Control Arm Shafts and Bearings or Bushings; Upper and Lower Ball Joints; Radius Arm and Bushings; Torsion Bars, Mounts,
and Bushings; Stabilizer Bar, Links and Bushings; Struts; Strut Bearing Plates; Spindle and Spindle Support; Wheel Bearings. Variable Dampening Suspension: Compressor;
Control Module; Dampening Actuator; Solenoid; Struts; Height Sensor; Mode Selector Switch; Seals and Gaskets.
12.
Enhanced Electrical: Automatic Climate Control
Programmer; Electronic Instrument Cluster; Mileage Computer; Distributor; Ignition Coil; Electronic Combination Entry System
(Does Not Include Transmitters and Receivers for Remote Locks); Cruise Control Module, Transducer, Servo and Amplifier; Powertrain
Control Module; Headlamp Motors; Power Window Motor; Power Seat Motor; Power Mirror Motor; Power Antenna Motor/Mast Assembly;
Convertible Top Motor; Power Sunroof Motor; Power Window Switch; Cruise Control Engagement Switch; Power Seat Switch; Power
Mirror Motor Switch; Rear Defogger Switch; Power Door Lock Actuator and Switch.
13.
Fuel Delivery: Fuel Injection Pump and Injectors; Vacuum
Pump; Fuel Tank; Fuel Sending Unit; and Metal Fuel Delivery Lines.
14.
Cooling: Engine Cooling Fan and Motor; Fan Clutch;
Belt Tensioner; Radiator; Heater Core; Thermostat; Blower Motor; and Hot Water Valve.
